RABUGGI DISASSEMBLY FOR PAINT 06-06-17 R.A.B. __ put on ramps, disconnect hand brake cables __ disconnect/remove tail & mkr. lights, back-up light, license, license light, wires, bag/label __ remove (2) REAR FENDERS, splash shields, separator, brace, welting; bag/label __ un-ramp __ remove door interior panels, hatch panel, rubber feet, aux latches*, bag/label <<< (*Zn plate) __ remove hatch latch hook, cables, brackets; bag/label __ remove door side mirrors, glass, scissor stays, latches, bag/label __ remove door latches, plates, aux. latches upper/lower*, pull handles*, bag/label <<< (*Zn plate) __ remove door hinge pins, bolts, hinges, snubbers & brackets; bag/label __ remove door and hatch weatherstrip, door latch strikers; bag/label __ set aside (2) DOORS and (1) HATCH __ remove rad. cap; disassemble/remove (4) HOOD PANELS, store hinge pin wires __ disassemble hood latch/bumper/grill hardware, (2) HOOD HANDLES; bag/label __ remove (2) COWL VENT FLAPS, bag/label screws __ remove cowl chafing strips (repair surface) __ remove seats, seat belts, bag screws __ remove steering wheel & shaft, bearings; remove lower shaft, store __ remove hand brake, shifter bezels/boots, store; cap shifter pocket __ disconnect/remove headlights, park lights __ remove (1) APRON & (2) SIGHT GAP PATCHES between front fenders, bag/label __ remove splash shields, (2) FRONT FENDERS, welting, hood latches; bag/label screws __ disconnect battery ground __ remove (2) STEEL HOOD SIDE BEAMS, bag/label screws __ remove hat channel from firewall & rad. shell, bag/label screws __ disconnect, remove windshield wiper motors, arms, torque brackets; store __ un-strap dash panel wiring harness, disconnect, label __ remove dash panel complete __ remove thru-firewall harness connectors, bag/label screws __ disconnect, remove ECM & DRAC; store __ remove cowl flap linkage __ remove inside rear view mirror __ remove rear glass panes, bag/label screws; clean off putty __ remove windshield glass & gaskets __ disconnect brake (not clutch) lines, remove master cylinders, reservoirs, pedals __ loosen (4) body mount bolts, store __ remove fuel filler tunnel, cap, neck, bezel, hose; bag/label, plug off tank pipe __ roll out, lift off (1) CABIN BODY SHELL